Accumulation and Decay Characteristics of Charges on Oil-Paper Insulated Surface Under High Frequency Electrical Aging Process

Nan WU; Xiaonan LI; He LI; Peng JIANG; Yixuan LI

doi:10.13648/j.cnki.issn1674-0629.2022.07.005

PDF(3159 KB)

South Power Sys Technol ›› 2022, Vol. 16 ›› Issue (7) : 40-45. DOI: 10.13648/j.cnki.issn1674-0629.2022.07.005

Accumulation and Decay Characteristics of Charges on Oil-Paper Insulated Surface Under High Frequency Electrical Aging Process

Nan WU ¹ ,
Xiaonan LI ² ,
He LI ¹ ,
Peng JIANG ¹ ,
Yixuan LI ²

Author information +

History +

Abstract

With the development of power electronic devices towards high frequency, large power and lightweight, high frequency becomes one of the important reasons of the high frequency transformers failures. In this paper, a high-frequency electrical aging experiment system is built, and the surface potential attenuation method is used to measure the surface charge accumulation and attenuation characteristics of oil paper insulation with different aging degrees. The results show that as the applied frequency increases, the amount of charge accumulated on the surface of the insulating paper decreases, and the charge attenuation rate increases first and then decreases. After high-frequency aging, the surface charge accumulation and attenuation rate of oil-paper insulation decreases with the increase of aging degree. When the frequency is lower than 5 kHz, the high-frequency heating effect on the surface of the insulating paper plays a leading role, and when the frequency is higher than 5 kHz, the charge dissipation time caused by the high frequency plays a leading role, causing the surface charge attenuation rate to increase first and then decrease. As the degree of high-frequency electrical aging increases, the probability of initial electron generation of oil-paper insulation decreases. Understanding the characteristics of surface charge accumulation and dissipation provides a theoretical basis for revealing the electrical aging mechanism of oil-paper insulation under high frequency.

Key words

high frequency square wave / oil-paper insulation / Nomex paper / electrical aging / charge accumulation / charge decay

Cite this article

EndNote

Ris (Procite)

Bibtex

Download Citations

Nan WU , Xiaonan LI , He LI , et al . Accumulation and Decay Characteristics of Charges on Oil-Paper Insulated Surface Under High Frequency Electrical Aging Process[J]. Southern Power System Technology. 2022, 16(7): 40-45 https://doi.org/10.13648/j.cnki.issn1674-0629.2022.07.005

References

List( Publishing order | Descend order by publishing year | Descend order by cited within ) Chart analysis

[1]	李子欣, 高范强, 赵聪, 等. 电力电子变压器技术研究综述[J]. 中国电机工程学报, 2018, 38(5): 1274-1289. LI Zixin, GAO Fanqiang, ZHAO Cong, et al. Research review of power electronic transformer technologies[J]. Proceedings of the CSEE, 2018, 38(5): 1274-1289. Cited in this article [2]

[2]	SHE X, HUANG A Q, BURGOS R. Review of solid-state transformer technologies and their application in power distribution systems[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2013, 1(3): 186-198.

[3]	FENG J, CHU W, ZHANG Z. Power electronic transformer-based railway traction systems: challenges and opportunities[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2017, 5(3): 1237-1253.

[4]	FILCHEV T, COOK D, WHEELER P, et al. High power, high voltage, high frequency transformer/rectifier for HV industrial applications[C]// 2008 13th International Power Electronics and Motion Control Conference, September1-3, Poznan, Poland. New York: IEEE, 2008: 1326-1331.

[5]	张爱军, 邢华栋, 任思宇, 等. 互联多端口电力电子变压器的建模与仿真技术[J]. 南方电网技术, 2020, 14(8): 66-75. ZHANG Aijun, XING Huadong, REN Siyu, et al. Modeling and simulation technology of interconnected multi-port power electronic transformer[J]. Southern Power System Technology, 2020, 14(8): 66-75. Cited in this article [1]

[6]

李晓楠, 刘凯, 杨雁, 等. 高频表面电荷输运对油纸绝缘局部放电的影响[J]. 中国电机工程学报, 2022, 42(3): 1223-1232.

Xiaonan

, LIU

Kai

, YANG

Yan

, et al. Effect of charge transportation on the partial discharge characteristics of oil-paper insulation under high frequency stress[J]. Proceedings of the CSEE, 2022, 42(3): 1223-1232.

Cited in this article [7]

[7]	赵义焜, 张国强, 郭润睿, 等. 高频变压器用耐高温型匝间绝缘材料的击穿特性[J]. 高电压技术, 2020, 46(2): 657-665. ZHAO Yikun, ZHANG Guoqiang, GUO Runrui, et al. Breakdown characteristics of heat-resistant inter-turn insulation materials in high-frequency transformers[J]. High Voltage Engineering, 2020, 46(2): 657-665.

[8]

赵义焜, 张国强, 韩冬, 等. 高频变压器用匝间绝缘材料沿面放电特性的实验研究[J]. 电工技术学报, 2019, 34(16): 3464-3471.

ZHAO

Yikun

, ZHANG

Guoqiang

, HAN

Dong

, et al. Study on surface discharge characteristics of inter-turn insulation materials in high-frequency transformers[J]. Transactions of China Electrotechnical Society, 2019, 34(16): 3464-3471.

Cited in this article [3]

[9]	FABIANI D, MONTANARI G C, CAVALLINI A, et al. Relation between space charge accumulation and partial discharge activity in enameled wires under PWM-like voltage waveforms[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2004, 11(3): 393-405. Cited in this article [1]

[10]

TAKIZAWA

, SUETSUGU

, MIYAKE

. Space charge behavior in covering insulating material for motor windings under applied voltage of square wave[C]// Proceedings of IEEE International Symposium on Electrical Insulating Materials, June 1-5, 2014, Niigata, Japan. New York: IEEE, 2014: 409-412.

Cited in this article [1]

[11]	IWATA T, MOMOSE T, MIYAKE H.Measurement of space charge distribution in coating material for motor wingings under square wave voltage [C]// 2016 IEEE International Conference on Dielectrics (ICD), July 3-7, 2016, Montpellier, France. New York: IEEE, 2016. Cited in this article [1]

[12]

MIMA

, IWATA

, MIYAKE

. Evaluation of electrical insulation characteristics of polyamide-imide film using masurement results of space charge distributions with an applied square wave voltage [C]//2017 3rd International Conference on Condition Assessment Techniques in Electrical Systems (CATCON), 16-18 November 2017, Rupnagar, India. New York: IEEE, 2017: 69-74.

Cited in this article [1]

[13]

MIMA

, MIYAKE

, TANAKA

.Measurement of space charge distribution in polyamide-imide film under square wave voltage practical environment for inverter-fed motor [C]// 2018 IEEE 2nd International Conference on Dielectrics (ICD), 01-05 July 2018, Budapest, Hungary. New York: IEEE, 2018.

Cited in this article [1]

[14]

MIMA

, MIYAKE

, TANAKA

.Dependence of duty ratio of square wave voltage on space charge accumulation property in motor winding coating insulating material [C]// 2018 12th International Conference on the Properties and Applications of Dielectric Materials (ICPADM), 20-24 May 2018, Xi’an, China. New York: IEEE,2018: 102-106.

Cited in this article [1]

[15]	王霞, 舒子航, 段胜杰, 等. 方波电压下交联聚乙烯中的空间电荷特性[J]. 高电压技术, 2020, 46(2): 634-639. WANG Xia, SHU Zihang, DUAN Shengjie, et al. Space charge accumulation property in XLPE under applied voltage of square wave[J]. High Voltage Engineering, 2020, 46(2): 634-639. Cited in this article [1]

[16]	李成榕, 齐波. 油纸绝缘结构的空间电场测量技术及应用评述[J]. 南方电网技术, 2013, 7(2): 1-9. LI Chengrong, QI Bo. Review on the measurement techniques for space electric field in oil-paper insulation and their application[J]. Southern Power System Technology, 2013, 7(2): 1-9. Cited in this article [1]

[17]	IEC. High-voltage B0902704 test techniques partial discharge measurements: IEC Std 60270—2000[S]. IEC, 2000. Cited in this article [1]

[18]	高宇, 王明行, 赵宁, 等. 固体绝缘材料表面电荷特性的研究进展[J]. 高电压技术, 2018, 44(8): 2628-2645. GAO Yu, WANG Minghang, ZHAO Ning, et al. Research progress in surface charge characteristics of solid insulating materials[J]. High Voltage Engineering, 2018, 44(8): 2628-2645. Cited in this article [1]

[19]	TATEMATSU A, HAMADA S, TAKUMA T. A study on the accuracy of surface charge measurement[J]. IEEE Transactions on Dielectrics & Electrical Insulation, 2002, 9(3): 406-415.

[20]	李奕萱, 高波, 李晓楠, 等. 热老化对Nomex绝缘纸表面电荷积聚消散特性的影响研究[J]. 中国电机工程学报, 2020, 40(17): 5707-5716. LI Yixuan, GAO Bo, LI Xiaonan, et al. Effect of thermal aging on surface charge accumulation and dissipation of nomex paper[J]. Proceedings of the CSEE, 2020, 40(17): 5707-5716. Cited in this article [3]

[21]	DU B, ZHU W, ZHANG J, et al. Surface and interface charge accumulation and decay of oil-paper insulation under DC voltage[J]. IEEE Transactions on Electrical Insulation, 2017, 24(2): 939-946. Cited in this article [1]

[23]

李奕萱, 高波, 李晓楠, 等. 多层油纸绝缘介质不同局放阶段的陷阱参数演变规律[J]. 高电压技术, 2021, 47(1): 260-268.

Yixuan

, GAO

, LI

Xiaonan

, et al. Evolution of trapping parameters of multi-layer oil-paper insulating medium at different partial discharge stages[J]. High Voltage Engineering, 2021, 47(1): 260-268.

Cited in this article [1]

[24]	LI Quanfu, LI Xiaonan, YANG Yan, et al. The evolution of trapping parameters on three-layer oil-paper of partial discharge degradation for on-board traction transformers[J]. IEEE Access, 2020, 8: 175651-175659. Cited in this article [2]

[25]	QU G, CUI H, ZHU Y, et al. Substantial improvement of the dielectric strength of cellulose-liquid composites: effects of traps at the nanoscale interface[J]. The Journal of Physical Chemistry Letters, 2020, 11(5): 1881-1889.

[26]	ZHU Y W, CUI H Z, QU G H, et al. Origin of superb electrical insulating capability of cellulose-liquid biphasic dielectrics by interfacial charge behaviors[J]. Applied Physics Letters, 2020, 117(4): 042906. Cited in this article [1]